2004-2006 Chevrolet Optra
Loss of headlamp low beam or daytime running light (DRL) as a result of melted instrument panel harness connector.
Models: 34,140.
What to do: Have dealer add direct connection splice clip to low-beam circuit to bypass faulty connector.

2007-2008 Chrysler Sebring and Dodge Avenger
Coolant overflow from recovery bottle may cause electrical short circuit. Could result in engine compartment fire.
Models: 3,700 vehicles with 2.4-litre engine.
What to do: Have dealer inspect cooling fan motor connector and install wiring harness overlay, and if necessary, replace fan motor.

2007 Cadillac CTS
Sunroof does not perform properly and can be closed after ignition is turned off and doors are opened.
Models: 1,134.
What to do: Have dealer install a wire harness.

2008 Mercedes-Benz C-Class
Safety-belt locking mechanism may not perform properly with older non-LATCH child restraint.
Models: 176.
What to do: Have dealer replace the rear outboard safety-belt assemblies.

2006-2008 BMW models
V8 engine operating in below-freezing temperatures coupled with low humidity may experience electrostatic discharge at fuel rails. Could result in stalled engine and loss of power steering.
Models: 2,148 2006-2008 BMW 550i, 2006-2007 BMW 650i Cabriolet, 2006-2007 BMW 650i Coupe, 2007 BMW X5.
What to do: Have dealer install additional ground cable between fuel rails and ground connection of ignition coils.

2002-2008 Kawasaki KLR650
Tightening torque may not have been properly applied to muffler mounting bolts. Muffler could separate from motorcycle, causing injury.
Models: 5,298.
What to do: Have dealer tighten muffler mounting bolts to proper torque.

2008 Volvo XC70
Incorrect software was programmed into Safety Restraint System (SRS) control module. Inflatable curtain and side impact air bag may not deploy as intended. May also cause SRS warning lamp to display message "SRS Airbag – Service Urgent."
Models: 644.
What to do: Have dealer update SRS control module software.

2008 Chrysler models
Bilingual air-bag visor warning labels may not have been installed.
Models: 4,200 2008 Dodge Caliber, 2008 Jeep Compass, 2008 Jeep Patriot.
What to do: Dealers will provide labels and installation instructions.

2002-2007 Suzuki motorcycles
Reflex reflectors fail to comply with requirements. At some angles light output is less than standard.
Models: 2,870 2002-2007 Suzuki GZ250, 2004-2007 Suzuki GS500/F.
What to do: Have dealer replace reflex reflectors with updated versions.

2002-2006 Nissan Altima and Sentra
Crank angle sensor may malfunction, causing engine to stall.
Models: 40,666 vehicles with 2.5-litre engine.
What to do: Have dealer reprogram Electronic Control Module (ECM).