Fuel System/Emissions
Sensors (O₂, or oxygen, sensor), emission-control devices (includes EGR), fuel-injection system, fuel gauge/sender, fuel pump, problems filling up the tank.
2023
Chevrolet Suburban
EPA MPG:
16 mpg
EPA MPG:
16 mpg
RECALL ALERT:
There are 4 recalls on this vehicle.
Learn More.
Shift your car buying experience
See how your top choices measure up on the features that matter most to you.
Reliability
Overall Reliability
We expect the 2025 Suburban will be less reliable than the average new car. This prediction is based on data from 2023 model and the Chevrolet brand score.
Most Common Trouble Spots
Common Trouble Spot
Common Trouble Spot
Owner Reported Trouble Spots
The Reliability score is based on our latest subscriber survey of 2023 Chevrolet Suburban owners. The owner comments describe problems respondents experienced with this vehicle.
Body Hardware
Windows, locks and latches, doors or sliding doors, tailgate, trunk or hatch, mirrors, seat controls (power or manual), seat belts, sunroof, convertible top, glass defect.
What Owners Say
"Right rear fold down seat's headrest would not lock in place. Was replaced under warranty"
Anonymous A., VA (2023 Chevrolet Suburban Z71 5.3-L V8)In-car Electronics
Infotainment system (audio, GPS, phone), rear entertainment system, backup or other camera/sensors, head-up display.
What Owners Say
"Many times the one calling the Suburban has their voice echoing back into the phone. The Suburban also drops calls while you're talking."
Anonymous A., GA (2023 Chevrolet Suburban Premier 5.3-L V8)Suspension/Steering
Shocks or struts, ball joints, tie rods, wheel bearings, alignment, steering linkage (includes rack and pinion), power steering (pumps and hoses, leaks), wheel balance, springs or torsion bars, bushings, electronic or air suspension.
Engine Major
Engine rebuild or replacement, cylinder head, head gasket, turbocharger or supercharger, timing chain or belt.
Electrical Accessories
Cruise control, clock, warning lights, body control module, keyless entry, wiper motor or washer, tire pressure monitor, interior or exterior lights, horn, gauges, 12V power plug, USB ports, alarm or security system, remote engine start, heated or cooled seats, heated steering wheel, headlights, automatic headlights, automatic wipers, wireless charging pad.
Engine Electrical
Alternator, starter, hybrid battery replacement, hybrid battery related systems, regular battery, battery cables, engine harness, coil, ignition switch, electronic ignition, spark plugs and wires failure, auto stop/start.
Drive System
Driveshaft or axle, CV joint, differential, transfer case, four-wheel-drive/all-wheel-drive components, driveline vibration, electrical failure, traction control, electronic stability control.
Brakes
Premature pad/rotor wear, pulsation or vibration, antilock system, parking brake, master cylinder, calipers, squeaking, brake failure, regenerative braking.
Exhaust
Muffler, pipes, catalytic converter, exhaust manifold, heat shields, leaks.
Climate System
AC compressor, blower (fan) motor, condenser, evaporator, heater system, automatic climate system, electrical failure, refrigerant leakage.
Engine Cooling
Radiator, cooling fan, water pump, thermostat, antifreeze leaks, overheating.
Transmission Major
Transmission rebuild or replacement, torque converter, premature clutch replacement.
Transmission Minor
Gear selector and linkage, transmission computer, transmission sensor or solenoid, clutch adjustment, rough shifting, slipping transmission, leaks.
Engine Minor
Accessory belts and pulleys, engine computer, engine mounts, engine knock or ping, fuel leaks, oil leaks.
Paint/Trim
Paint (fading, chalking, peeling, or cracking), loose interior or exterior trim or moldings, rust.
Noises/Leaks
Squeaks, rattles, wind noises, seals and/or weather stripping, air and water leaks.
2023 SUVs Reliability
This Car
0
100
Chevrolet Suburba...
vs. Similar Cars
Buick Enclave
Chevrolet Tahoe
Ford Expedition
GMC Yukon
GMC Yukon XL
Chevrolet vs. Other New Car Brands Reliability
Overall Reliability Verdict
POTENTIAL TROUBLE SPOTS
Reliability indicates how models have performed in the past, providing the basis for predicting
how the vehicles will hold up in the year ahead. These charts provide the most comprehensive
reliability information available to consumers. Based on information received from our latest
subscriber survey for over 300,000 vehicles, our reliability history charts give
you a rundown on how 2000 through 2024 vehicles are holding up in 20
potential trouble spots, ranging from the engine, transmission, electric motor, EV charging, and
brakes to power equipment and the electrical accessories.
NA indicates that we did not receive a large enough sample size to provide
data for a specific year. An X indicates that the vehicle was not manufactured for a specific year.
Recalls
PROVIDED BY
ENGINE AND ENGINE COOLING
Apr 24, 2025
Engine failure increases the risk of a crash.
Summary:
General Motors LLC (GM) is recalling certain 2021-2024 Cadillac Escalade and Escalade ESV, Chevrolet Silverado 1500, Suburban, and Tahoe, GMC Sierra 1500, Yukon, and Yukon XL vehicles equipped with a 6.2L V8 gas engine. The connecting rod and/or crankshaft engine components may have manufacturing defects that can lead to engine damage and engine failure.
What should you do:
Dealers will inspect the engine, and as necessary, repair or replace the engine. For vehicles that pass inspection, dealers will add higher viscosity oil, install 6 oil fill cap, replace the oil filter, and update the owner's manual. Repairs will be performed free of charge. Owner notification letters were mailed June 6, 2025. Owners may contact Cadillac customer service at 1-800-333-4223, Chevrolet customer service at 1-800-222-1020, or GMC customer service at 1-800-462-8782. GM's number for this recall is N252494000.
For more information:
Owners may also contact the National Highway Traffic Safety Administration Vehicle Safety Hotline at 1-888-327-4236 (TTY 1-888-275-9171) or go to www.nhtsa.gov.
NHTSA CAMPAIGN ID Number:
25V274000
Potential Number of Units Affected:
597571
SERVICE BRAKES, HYDRAULIC
Sep 12, 2024
Without a warning light, the vehicle may be driven with low brake fluid, which can reduce braking performance and increase the risk of a crash.
Summary:
General Motors, LLC (GM) is recalling certain 2023 Chevrolet Silverado 1500, GMC Sierra 1500, 2023-2024 Chevrolet Tahoe, Suburban, GMC Yukon, Yukon XL, Cadillac Escalade, and Escalade ESV vehicles. The electronic brake control module software may fail to display a warning light when a loss of brake fluid occurs. As such, these vehicles fail to comply with the requirements of Federal Vehicle Safety Standard number 135, "Light Vehicle Brake Systems."
What should you do:
The Electronic Brake Control Module (eBCM) software will be updated through an over-the-air (OTA) update or by a dealer, free of charge. Owner notification letters were mailed October 25, 2024. Owners can contact GMC customer service at 1-800-462-8782, Chevrolet customer service at 1-800-222-1020, or Cadillac customer service at 1-800-458-8006. GM's number for this recall is N242447990.
For more information:
Owners may also contact the National Highway Traffic Safety Administration Vehicle Safety Hotline at 1-888-327-4236 (TTY 1-800-424-9153), or go to www.nhtsa.gov.
NHTSA CAMPAIGN ID Number:
24V674000
Potential Number of Units Affected:
449671
SUSPENSION
Sep 20, 2023
A broken suspension bolt can result in misalignment of the rear wheel, increasing the risk of a crash.
Summary:
General Motors, LLC (GM) is recalling certain 2023 Cadillac Escalade, Escalade ESV, Chevrolet Suburban, Chevrolet Tahoe, GMC Yukon, and Yukon XL vehicles. The rear suspension outer control arm bolts may not have been properly heat-treated, which can cause the bolts to break.
What should you do:
Dealers will replace both rear suspension outer control arm bolts, free of charge. Owner notification letters were mailed November 14, 2023. Owners may contact Chevrolet customer service at 1-800-222-1020; Cadillac customer service at 1-800-458-8006; and GMC customer service at 1-800-462-8782. GM's number for this recall is N232415910.
For more information:
Owners may also contact the National Highway Traffic Safety Administration Vehicle Safety Hotline at 1-888-327-4236 (TTY 1-800-424-9153), or go to www.nhtsa.gov.
NHTSA CAMPAIGN ID Number:
23V642000
Potential Number of Units Affected:
189
EXTERIOR LIGHTING
Dec 08, 2022
DRLs that do not deactivate as intended may result in a glare, reducing visibility, and increasing the risk of a crash.
Summary:
General Motors, LLC (GM) is recalling certain 2020-2023 Cadillac CT4 and CT5; 2021-2023 Buick Envision; and 2022-2023 Cadillac Escalade and Escalade ESV, Chevrolet Silverado 1500, Suburban, Tahoe, GMC Sierra 1500, Yukon, and Yukon XL vehicles. The daytime running lights (DRLs) may not deactivate when the headlights are on. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 108, "Lamps, Reflective Devices, and Associated Equipment."
What should you do:
The body control module software will be updated by a dealer, or through an over-the-air (OTA) update, free of charge. Owner notification letters were mailed January 23, 2023. Owners may contact GMC customer service at 1-888-988-7267, Chevrolet customer service at 1-800-222-1020, or Cadillac customer service at 1-800-458-8006. GM's number for this recall is N222386380. This recall expands previous recall number 22V-827.
For more information:
Owners may also contact the National Highway Traffic Safety Administration Vehicle Safety Hotline at 1-888-327-4236 (TTY 1-800-424-9153), or go to www.nhtsa.gov.
NHTSA CAMPAIGN ID Number:
22V903000
Potential Number of Units Affected:
740108
Check Vehicle for Unrepaired Recalls
Enter a valid 17-character VIN
Enter a valid 17-character VIN
"Fuel pump control module failed. Car stopped in the middle of the street. Could not release the parking brake or put it in neutral yo be towed. AAA had to get another truck. Dealer did not have the part - took 3 days to get. Warranty repair but 2 days for them to get me a loaner. BTW, this part cannot be installed by the owner as it must be programmed by the CHEVROLET through the dealer"
Anonymous A., FL (2023 Chevrolet Suburban LT 5.3-L V8)