Engine Electrical
Alternator, starter, hybrid battery replacement, hybrid battery related systems, regular battery, battery cables, engine harness, coil, ignition switch, electronic ignition, spark plugs and wires failure, auto stop/start.
2005
Chevrolet Silverado 2500HD
EPA MPG:
NA
EPA MPG:
NA
RECALL ALERT:
There is 1 recall on this vehicle.
Learn More.
Reliability
Overall Reliability
The 2005 Silverado 2500HD is less reliable than other cars from the same model year.
Most Common Trouble Spots
Common Trouble Spot
Common Trouble Spot
Owner Reported Trouble Spots
The Reliability score is based on our latest subscriber survey of 2005 Chevrolet Silverado 2500HD owners. The owner comments describe problems respondents experienced with this vehicle.
Body Hardware
Windows, locks and latches, doors or sliding doors, tailgate, trunk or hatch, mirrors, seat controls (power or manual), seat belts, sunroof, convertible top, glass defect.
What Owners Say
"Tailgate latch broke and needed to be replaced."
Anonymous, CA (2005 Chevrolet Silverado 2500HD LT 8.1-L V8)Climate System
AC compressor, blower (fan) motor, condenser, evaporator, heater system, automatic climate system, electrical failure, refrigerant leakage.
What Owners Say
"Air conditioning clutch went out, so I had the a/c compressor replaced at the same time. I have 185000 miles on my truck."
Anonymous A., CA (2005 Chevrolet Silverado 2500HD LS 8.1-L V8)Suspension/Steering
Shocks or struts, ball joints, tie rods, wheel bearings, alignment, steering linkage (includes rack and pinion), power steering (pumps and hoses, leaks), wheel balance, springs or torsion bars, bushings, electronic or air suspension.
What Owners Say
"Worn 185000 miles. Routine maintenance."
Anonymous A., CA (2005 Chevrolet Silverado 2500HD LS 8.1-L V8)Paint/Trim
Paint (fading, chalking, peeling, or cracking), loose interior or exterior trim or moldings, rust.
What Owners Say
"clear coat faded and makes the paint look faded. Exterior trim is also faded."
Anonymous, CA (2005 Chevrolet Silverado 2500HD LT 8.1-L V8)Exhaust
Muffler, pipes, catalytic converter, exhaust manifold, heat shields, leaks.
What Owners Say
"Just put in new break lines."
Anonymous, WI (2005 Chevrolet Silverado 2500HD Unsure 6.0-L V8)Engine Major
Engine rebuild or replacement, cylinder head, head gasket, turbocharger or supercharger, timing chain or belt.
Electrical Accessories
Cruise control, clock, warning lights, body control module, keyless entry, wiper motor or washer, tire pressure monitor, interior or exterior lights, horn, gauges, 12V power plug, USB ports, alarm or security system, remote engine start, heated or cooled seats, heated steering wheel, headlights, automatic headlights, automatic wipers, wireless charging pad.
Transmission Minor
Gear selector and linkage, transmission computer, transmission sensor or solenoid, clutch adjustment, rough shifting, slipping transmission, leaks.
Fuel System/Emissions
Sensors (O₂, or oxygen, sensor), emission-control devices (includes EGR), fuel-injection system, fuel gauge/sender, fuel pump, problems filling up the tank.
Engine Cooling
Radiator, cooling fan, water pump, thermostat, antifreeze leaks, overheating.
Transmission Major
Transmission rebuild or replacement, torque converter, premature clutch replacement.
Engine Minor
Accessory belts and pulleys, engine computer, engine mounts, engine knock or ping, fuel leaks, oil leaks.
Drive System
Driveshaft or axle, CV joint, differential, transfer case, four-wheel-drive/all-wheel-drive components, driveline vibration, electrical failure, traction control, electronic stability control.
In-car Electronics
Infotainment system (audio, GPS, phone), rear entertainment system, backup or other camera/sensors, head-up display.
Brakes
Premature pad/rotor wear, pulsation or vibration, antilock system, parking brake, master cylinder, calipers, squeaking, brake failure, regenerative braking.
Noises/Leaks
Squeaks, rattles, wind noises, seals and/or weather stripping, air and water leaks.
2005 Pickup Trucks Reliability
This Car
0
100
Chevrolet vs. Other New Car Brands Reliability
Overall Reliability Verdict
POTENTIAL TROUBLE SPOTS
Reliability indicates how models have performed in the past, providing the basis for predicting
how the vehicles will hold up in the year ahead. These charts provide the most comprehensive reliability
information available to consumers. Based on information received from our latest subscriber survey for
about 380,000 vehicles, our reliability history charts give
you a rundown on how 2000 through 2025 vehicles are holding up in 20 potential
trouble spots, ranging from the engine, transmission, electric motor, EV charging, and brakes,
to power equipment and the electrical accessories.
Recalls
PROVIDED BY
WHEELS
Jun 04, 2007
DAMAGE OCCURS TO THE VEHICLE COMPONENTS AROUND THE RIMS ON THE FRONT OF THE VEHICLE. THE ANTI-LOCK BRAKE SENSOR WIRES COULD BE CUT.
Summary:
ON CERTAIN VEHICLES EQUIPPED WITH SERIES 0307, HR0307A, HR0307B, HR1000A OR HR1500HB HY--RAIL GUIDE WHEEL EQUIPMENT, THESE STEERING STOPS MAY NOT BE CORRECTLY INSTALLED.
What should you do:
THE VEHICLE'S FRONT TIRES, WHEELS, UPPER CONTROL ARMS, AND ANTI-LOCK BRAKE SENSOR WIRES WILL BE INSPECTED. IF ANY DAMAGE, WEAR, NICKS, GOUGES, CUT OR FRAYED WIRES, ARE FOUND, CONTROL ARM GUARD PLATES WILL BE NEEDED AND/OR THE STEERING STOPS WILL BE REPLACED. THE ANTI-LOCK BRAKE SENSOR WIRES WILL ALSO BE RELOCATED. OWNERS WERE NOTIFIED ON FEBRUARY 23, 2007. OWNERS MAY CONTACT HARSCO AT 1-507-235-7212.
For more information:
CUSTOMERS MAY CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY: 1-800-424-9153); OR GO TO HTTP://WWW.SAFERCAR.GOV.
NHTSA CAMPAIGN ID Number:
07V228000
Potential Number of Units Affected:
700
Check Vehicle for Unrepaired Recalls
Enter a valid 17-character VIN
Enter a valid 17-character VIN
"The seat turns on by itself"
Anonymous, (2005 Chevrolet Silverado 2500HD LT 6.6-L V8 diesel)